Effect of Hydrogen Charging on Mechanical Twinning, Strain Hardening, and Fracture of ‹111› and ‹144› Hadfield Steel Single Crystals
- Authors: Astafurova E.G.1, Maier G.G.1, Melnikov E.V.1, Moskvina V.A.2, Vojtsik V.F.2, Zakharov G.N.1, Smirnov A.I.3, Bataev V.A.3
-
Affiliations:
- Institute of Strength Physics and Materials Science, Siberian Branch
- National Research Tomsk Polytechnic University
- Novosibirsk State Technical University
- Issue: Vol 21, No 3 (2018)
- Pages: 263-273
- Section: Article
- URL: https://journals.rcsi.science/1029-9599/article/view/192241
- DOI: https://doi.org/10.1134/S1029959918030116
- ID: 192241
Cite item
Abstract
This paper studies the effect of electrolytic hydrogen charging on the plastic deformation and fracture of Hadfield steel single crystals oriented for tension along the ‹111› and ‹144› directions, which the major deformation mechanism is mechanical twinning. Electrolytic hydrogen charging for five hours at a current density of 100 A/m2 slightly affects the stages of plastic flow, deformation mechanism, and the value of uniform elongation of ‹111› and ‹144› single clreystals. Hydrogen saturation causes shear microlocalization and a decrease of the strain hardening coefficient in twinning in one system, but slightly affects the strain hardening characteristics in multiple twinning. Hydrogen charging increases the fraction of the brittle component on fracture surfaces and leads to microand macrocracking near the fracture zone on the lateral surface of deformed specimens. It has been found experimentally that the stress relaxation rate in loaded ‹111› single clreystals after hydrogen saturation decreases. Mechanisms of describing this phenomenon have been proposed.
Keywords
About the authors
E. G. Astafurova
Institute of Strength Physics and Materials Science, Siberian Branch
Author for correspondence.
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634055
G. G. Maier
Institute of Strength Physics and Materials Science, Siberian Branch
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634055
E. V. Melnikov
Institute of Strength Physics and Materials Science, Siberian Branch
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634055
V. A. Moskvina
National Research Tomsk Polytechnic University
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634050
V. F. Vojtsik
National Research Tomsk Polytechnic University
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634050
G. N. Zakharov
Institute of Strength Physics and Materials Science, Siberian Branch
Email: elena.g.astafurova@gmail.com
Russian Federation, Tomsk, 634055
A. I. Smirnov
Novosibirsk State Technical University
Email: elena.g.astafurova@gmail.com
Russian Federation, Novosibirsk, 630073
V. A. Bataev
Novosibirsk State Technical University
Email: elena.g.astafurova@gmail.com
Russian Federation, Novosibirsk, 630073