Comparative tests of fly ash powder as solid demulsifiers


Cite item

Full Text

Abstract

This work investigates the effectiveness of fly ash particles as a solid demulsifier for destabilizing an oil-water emulsion and effectively removing water. The size of the fraction in the used solid powder does not exceed 40 microns in diameter. The demulsifier consists mainly of hematite (Fe2O3) and corundum (Al2O3) phases. The introduction of fly ash into the oil emulsion leads to demulsification of water from oil. The dosage of the powder ranged from 0.1 to 1 g. An increase in the dosage of fly ash leads to a rapid discharge of water from the emulsion. The study identifies the demulsifying properties of fly ash powder. Also, upon redispersion of demulsified samples, no re-emulsion was observed, as a result of which, it can be assumed that fly ash powder can contribute to deasphalting of oil-water emulsion. Reuse of industrial waste is an important method for improving the ecological state of the country.

Full Text

Restricted Access

About the authors

M. A. Mysakhanov

Казахский национальный университет им. Аль-Фараби

Email: mysahanov@gmail.com
магистр ТПУ по специальности «физика» Алматы

A. S. Zhakypov

Казахский национальный университет им. Аль-Фараби

Email: szhakupovalibek@gmail.com
докторант PhD, МНС Алматы

A. M. Bakhadur

Казахский национальный университет им. Аль-Фараби

Email: askar.bakhadur@gmail.com
докторант PhD, МНС Алматы

N. V. Khan

Казахский национальный университет им. Аль-Фараби

Email: mysahanov@gmail.com
докторант PhD КазНУ, МНС Алматы

E. Erlanuly

АО «Казахстанско-Британский технический университет»

Email: yerlanuly@physics.kz
докторант PhD, научный сотрудник Алматы

M. T. Gabdullin

АО «Казахстанско-Британский технический университет»

Email: m.gabdullin@kbtu.kz
и.о. ректора, Председателя Правления, канд. физ.-мат. наук, докт. PhD по физике плазмы, профессор Алматы

References

  1. Позднышев Г.Н. Стабилизация и разрушение нефтяных эмульсий. – М., Недра, 1982, 221 с.
  2. Гани Х.Ф. Физико-химические факторы образования и разрушения водонефтяных эмульсий. Дисс. канд. техн. наук. – М., 1976, 319 с.
  3. Петров А.А., Позднышев Г.Н. Физико-химические основы процесса обезвоживания нефти и очистка сточных вод. – М., Недра, 1971.
  4. Нефть. Общие технические условия. – СТ РК 1347-2005 (ГОСТ Р 51858-2002, MOD).
  5. Ермаков С. А., Мордвинов А. А. О влиянии асфальтенов на устойчивость водонефтяных эмульсий. – Нефтегазовое дело, 2007, № 1, 9 с.
  6. Месторождения нефти и газа Казахстана. Справочник. Под. редакцией Абдулина А.А. – М., Недра, 1996.
  7. Ahmad A. Adewunmi, Abduljamiu O. Amao. Demulsification and breaking mechanism of variable quartz concentrates obtained from sand. – Journal of Petroleum Science and Engineering, 2020, v. 192/
  8. Ahmad A. Adewunmia, Muhammad Shahzad Kamala, Theis Ivan Solling. Palm oil fuel ash (POFA) as a demulsifier for crude oil emulsions: Performance and mechanism. – Journal of Petroleum Science and Engineering, 2019, v.183.
  9. Maryam Razi, Mohammad Reza Rahimpour, Abdolhossein Jahanmiri. Effect of a Different Formulation of Demulsifiers on the Efficiency of Chemical Demulsification of Heavy Crude Oil. – Journal of chemical and engineering data, 2011, v. 56, р. 2936-2945.

Copyright (c) 2021 Mysakhanov M.A., Zhakypov A.S., Bakhadur A.M., Khan N.V., Erlanuly E., Gabdullin M.T.

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

This website uses cookies

You consent to our cookies if you continue to use our website.

About Cookies