Analysis of the Hydrodynamics of Swirling Flows in Direct-Flow Cyclones
- 作者: Toptalov V.1, Chesnokov Y.1, Flisyuk O.1, Martsulevich N.1, Likhachev I.1
-
隶属关系:
- St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
- 期: 卷 96, 编号 1 (2023)
- 页面: 112-120
- 栏目: Articles
- URL: https://journals.rcsi.science/0044-4618/article/view/141706
- DOI: https://doi.org/10.31857/S0044461823010139
- EDN: https://elibrary.ru/HVVWFV
- ID: 141706
如何引用文章
详细
A mathematical model is presented that describes the movement of gas in a direct-flow cyclone. The equations of motion of the gas phase were solved and profiles for the tangential and axial components of gas velocity were derived based on them. The results obtained are compared with the results of numerical simulation. The latter was carried out in the FlowVision software using the SST turbulence model. Via numerical calculations the change in the tangential and axial components of the gas velocity was determined at distances of 110, 150, 200, and 250 mm from the plate turbulator, or cyclone swirler.
作者简介
V. Toptalov
St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
Email: acjournal.nauka.nw@yandex.ru
Yu. Chesnokov
St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
Email: acjournal.nauka.nw@yandex.ru
O. Flisyuk
St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
Email: acjournal.nauka.nw@yandex.ru
N. Martsulevich
St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
Email: acjournal.nauka.nw@yandex.ru
I. Likhachev
St. Petersburg State Institute of Technology (Technical University), 190013, St. Petersburg, Russia
编辑信件的主要联系方式.
Email: acjournal.nauka.nw@yandex.ru
参考
- Cristobal C., Gil A. Modeling the gas and particle flow inside cyclone separators // Progress Energy Combust. 2007. V. 33 N 5. P. 409-452. https://doi.org/10.1016/j.pecs.2007.02.001
- Peng W., Hoffmann A. C., Dries H. W.-A., Regelink M. A., Stein L. E. Experimental study of the vortex-end in centrifugal separators: The Nature of the vortex end // Chem. Eng. Sci. 2005. V. 60. P. 6919-692828. https://doi.org/10.1016/j.ces.2005.06.009
- Biegger C., Sotgiu C., Weigand B. Numerical investigation of flow and heat transfer in a swirl tube // Int. J. Therm. Sci. 2015. V. 96. P. 319-330. https://doi.org/10.1016/j.ijthermalsci.2014.12.001
- Seibold F., Weigand B. Numerical analysis of the flow pattern in convergent vortex tubes for cyclone cooling applications // Int. J. Heat Fluid Flow. 2021. V. 90. https://doi.org/10.1016/j.ijheatfluidflow.2021.108806
- Bruschewski M., Grundmann S. Schiffer H.-P. Considerations for the design of swirl chambers for the cyclone cooling of turbine blades and for other applications with high swirl intensity // Int. J. Heat Fluid Flow. 2020. V. 86. ID 108670. https://doi.org/10.1016/j.ijheatfluidflow.2020.108670
- Novotny P., Weigand B., Marsik F., Biegger C., Tomas M. Flow structures in a swirl flow - vortex breakdown condition //j. Phys. 2018. Ser. 1045. ID 012031. https://doi.org/10.1088/1742-6596/1045/1/012031
- Tianxing Z., Alshehhi M., Khezzar L., Xia Y., Kharoua N. Experimental investigation of confined swirling flow and its interaction with a bluff body //j. Fluids Eng. 2019. V. 142. N 1. ID 011102.
- Шиляев М. И., Шиляев А. М. Моделирование процесса пылеулавливания в прямоточном циклоне. 1. Аэродинамика и коэффициент диффузии частиц в циклонной камере // Теплофизика и аэромеханика. 2003. Т. 10. № 2. С. 157-170.
- Тарасова Л. А., Терехов М. А., Трошкин О. А. Расчет гидравлического сопротивления вихревого аппарата // Хим. и нефтегаз. машиностроение. 2004. № 2. С. 11-12.
- Grundmann S., Wassermann F., Lorenz R., Jung B., Tropea C. Experimental investigation of helical structures in swirling flows // Int. J. Heat Fluid Flow. 2012. V. 37. P. 51-63. https://doi.org/10.1016/j.ijheatfluidflow.2012.05.003
- Huang L., Deng S., Chen Z., Guan J., Chen M. Numerical analysis of a novel gas-liquid pre-separation cyclone // Sep. Purif. Technol. 2018. V. 194. P. 470- 479. https://doi.org/10.1016/j.seppur.2017.11.066
- Bruschewski M., Scherhag C., Schiffer H.-P., Grundmann S. Influence of channel geometry and flow variables on cyclone cooling of turbine blades //j. Turbomach. 2016. V. 138. N 6. ID 061005. https://doi.org/10.1115/1.4032363
- Mikheev N., Saushin I., Paereliy A., Kratirov D., Levin K. Cyclone separator for gas-liquid mixture with high flux density // Powder Technol. 2018. V. 339. P. 326-333. https://doi.org/10.1016/j.powtec.2018.08.040.
- Турубаев Р. Р., Шваб А. В. Численное исследование аэродинамики закрученного потока в вихревой камере комбинированного пневматического аппарата // Вестн. Том. гос. ун-та. Математика и механика. 2017. № 47. С. 87-98. https://doi.org/10.17223/19988621/47/9
- Николаев А. Н., Харьков В. В. Описание профилей окружной и осевой компонент скорости в полом вихревом аппарате // Вестн. Казан. технол. ун-та. 2016. № 17. С. 71-74.
- Yu G., Dong S., Yang L., Yan, D., Dong K., Wei Y., Wang B. Experimental and numerical studies on a new double-stage tandem-nesting cyclone // Chem. Eng. Sci. 2021. V. 236. ID 116537. https://doi.org/10.1016/j.ces.2021.116537
- Li L., Du C., Chen X., Wang J., Fan X. Numerical study on flow and heat transfer behavior of vortex and film composite cooling //j. Mech. Sci. Technol. 2018. V. 32. N 6. P. 2905-2917. https://doi.org/10.1007/s12206-018-0547-4
- Yang C., Jeng D., Yang Y.-J., Chen H.-R., Gau C. Experimental study of pre-swirl flow effect on the heat transfer process in the entry region of a convergent pipe // Exp. Therm. Fluid Sci. 2011. V. 35. N 1. P. 73-81. https://doi.org/10.1016/j.expthermflusci. 2010.08.008
- You Y., Seibold F., Wang S., Weigand B., Gross U. URANS of turbulent flow and heat transfer in divergent swirl tubes using the k-Ω SST turbulence model with curvature correction // Int. J. Heat Mass Transf. 2020 V. 159. ID 120088. https://doi.org/10.1016/j.ijheatmasstransfer.2020.120088
- Платонов Д. В, Минаков А. В., Дектерев А. А., Сентябов А. В. Численное моделирование пространственных течений с закруткой потока // Компьютер. исслед. и моделирование. 2013. Т. 5. № 4. С. 635-648. https://doi.org/10.20537/2076-7633-2013-5-4-635-648
- Маликов З. М., Мадалиев М. Э. Математическое моделирование турбулентного течения в центробежном сепараторе // Вестн. Tом. гос. ун-та. 2021. № 71. C. 121-138. https://doi.org/10.17223/19988621/71/10
- Усманова Р. Р., Жернаков В. С. Моделирование движения закрученного потока в динамическом газопромывателе // Вестн. УГАТУ. 2013. Т. 17. № 1 (54). С. 63-67.
- Narasimha M., Brennan M. S., Holtham P. N., Napier- Munn T. J. A comprehensive CFD model of dense medium cyclone performance // Miner Eng. 2007. V. 20. N 4. P. 414-426. https://doi.org/10.1016/j.mineng.2006.10.004
- Mousavi S. M., Ghadimi B., Kowsary F. Numerical study on the effects of multiple inlet slot configurations on swirl cooling of a gas turbine blade leading edge // Int.Commun. Heat Mass Transf. 2018. V. 90. P. 34-43. https://doi.org/10.1016/j. icheatmasstransfer.2017.10.012
- Biegger C., Rao Y., Weigand B. Flow and heat transfer measurements inswirl tubes with one and multiple tangential inlet jets for internal gas turbine blade cooling // Int. J. Heat Fluid Flow. 2018. V. 73. P. 174-187. https://doi.org/10.1016/j.ijheatfluidflow.2018.07.011
- Волк А. М. Движение твердых частиц в закрученном потоке // Энергетика. Изв. вузов и энергетических объединений СНГ. 2009. № 3. C. 77-81.
- Чесноков Ю. Г., Бауман А. В., Флисюк О. М. Расчет поля скоростей жидкости в гидроциклоне // ЖПХ. 2006. Т. 79. № 5. С. 783-786.
- Flisiyk O. M., Martsulevich N. A., Toptalov V. S. Theoretical and experimental analysis of dependence of efficiency of direct-flow cyclone on geometry of separating chamber // ChemChemTech. 2021. V. 64. N 8. С. 99-106. https://doi.org/10.6060/ivkkt.20216408.6419
- Bloor M. I. G., Ingham D. B. The flow in industrial cyclone //j. Fluid Mech. 1987. V. 178. P. 507-519.
- Гольдштик М. А. Вихревые потоки. Новосибирск: Наука, 1981. 366 с.
- Barber T. A. On the Beltramian motion of the bidirectional vortex in a conical cyclone //j. Fluid Mech. 2017. V. 828. P. 708-732. https://doi.org/10.1017/jfm.2017.494
- Majdalani J. Helical solutions of the bidirectional vortex in a cylindrical cyclone: Beltramian and Trkalian motions //Fluid Dyn. Res. 2012. V. 44. ID 065506. https://doi.org/10.1088/0169-5983/44/6/065506